Technical Parameters of Oil-free Screw Air Type Compressor
機器名稱 | 噴水無油螺桿空氣壓縮機 |
壓縮空氣狀態 | 100% 不含油 |
電壓 | 380電壓/50HZ/3P, 220電壓/50HZ/3P,400電壓/50HZ/3P, 415電壓/50HZ/3P, 或60赫茲, 或定制 |
工作壓力 | 常壓: 3 酒吧, 8 酒吧, 10酒吧, (高壓可定制) |
壓縮機功率 | 7.5 千瓦, 11 千瓦, 15 千瓦, 18 千瓦, 22 千瓦它 250 千瓦 |
空運 | 0.8立方米/分鐘至 40 立方米/分鐘 @10 巴 |
空氣壓縮機噪音 | 60D b(A) 至 85 分貝(A) |
駕駛類型 | 直接驅動 |
冷卻類型 | 風冷或水冷 |
衛生材料 | 304 不銹鋼主機, 管道和儲罐 |
壓縮機主機 | 單螺桿主機 |
應用: | 製藥, 食物, 醫療的, 飲料, 氧&氮氣, 精密機床 |
Features of Water Injected Screw Compressor
(1) High Efficiency
潤滑水可以吸收大量的壓縮熱. 所以提高了壓縮效率. 除了, 水可以達到氣密性. 因此, the efficiency of oil-free screw compressor is high. 優於一般乾式螺桿壓縮機. 此外, 水的比熱容大. 工作過程類似於等溫壓縮. Theoretically, there is no clearance volume. 壓縮室溫度可降低至接近進氣溫度. So it can reduce the workload of refrigerated air dryers.
(2) Low Noise
The motor is directly connected to the screw. 所以沒有中間傳動齒輪. 此外, 潤滑油水還可以降低高頻壓縮產生的噪音. 而且, 無油螺桿壓縮機具有卓越的功率平衡系統. 能有效抑制振動源.
(3) Oil-free Compressed Air
The water-injected compressor is a common oil-free screw air compressor. 它不使用潤滑油. 所以壓縮空氣是 100% 不含任何油. 此外, 排出的水也是無油的. So no need for special treatment. 符合環保要求.
Why Choose The Lingyu Oilless Screw Type Compressor?
(1) Long Lifetime Full 304 Stainless Steel Single-screw Airend
無油主機採用PEEK轉子. 轉子及其他部件均 304 不銹鋼. 因此保證空氣含油量為等級 0. 我們的主機生產工藝來自日本. 除了, 我們使用原裝SKF軸承.
The compression volume ratio of our oil-free screw air compressor is ≥ 95%. 設計使用壽命為 15 年. 它可以連續運行 24 一天幾個小時. 而且, 結構好. 因此振動很小.
There are two-star wheels on both sides of the screw. 因此噴水螺桿壓縮機沒有不平衡慣性力. 並且螺桿上的軸向力和徑向力也相互抵消.
(2) Completely Oil-free Air Quality
Oil-free screw compressor replaces oil with water. 所以有 4 主要好處, that is lubrication, 冷卻, sealing, and noise reduction. It can provide high-quality 100% 無油空氣. 無污染. 排出的水也不需要特殊處理. 由於水的作用,這是一種理想的等溫壓縮. Compared with a dry oil-free compressor, 風量增加 15%.
(3) Superior Electrical Control System
每台空壓機均配有微電腦控制系統. 而且, 具有自診斷和保護功能. 面板可顯示噴水螺桿壓縮機的實際運行情況.
If the compressor fails, 系統會做出相應的反應. 這樣用戶就可以及時更換零件. 和 485 interfaces, it has a remote control. 所以, 保證安全運行 24 一天幾個小時.
(4) 節能
40,000 無故障工作數小時, free maintenance, high starting torque, and direct drive.
(5) 304 Stainless Steel Air And Water Separation Tank
分離罐及管道也採用SS304. 所以不會有腐蝕.
(6) Pure Copper Radiator
The air-cooled oil-free screw air compressor uses a copper radiator. 所以散熱穩定高效. 而且它還有一個靜音風扇.
(7) Power-saving Air Capacity Adjustment
當空氣消耗量減少時, 系統壓力開始增加. 控制器接收信號. 開始逐漸減小進氣門開度. 此時, the airflow volume of the oil-free screw air compressor will also decrease. 當然, 電機電流也會下降. 反過來, 當燃氣消耗增加時, 系統壓力開始下降. 進氣門開度會增大. 此時, the airflow of water injected screw compressor will also increase.
How Does Water Injected Oil Free Rotary Screw Air Compressor Work?
其工作原理與乾式無油空壓機不同. 注水壓縮機只有一顆螺桿.
The screw and the two-star wheels form a meshing pair. 通常, there are six grooves on the screw. 每個星輪齒都會與之嚙合. 螺槽有上下空間. 各自實現壓縮機的工作過程. Oil-free screw compressor generates pressure. 壓縮期間, there will inject lubricating water into the compressor chamber.
工作時, 轉子之間有純水噴淋冷卻. 從而淨化空氣. 同時, 轉子與純水形成良好的水膜密封. 使系統效率超過 95%. 所以, it can realize full energy savings.
The airend compress the water-air mixture. 然後進入不銹鋼水氣分離器. 將它們機械分離成壓縮空氣和純水. 系統溫度低於45℃. 所以壓縮空氣的含水量小於80g/m3.
壓縮空氣將位於分離器頂部. 它們通過最小壓力閥並進入排氣口. Then it will be discharged. 純化水位於分離器底部. The filter will remove impurities in the water. 冷卻後, the water enters the water-injected screw compressor again. 所以它開始第二個壓縮週期. 無油螺桿空壓機可實現自動換水. 所以, 它降低了勞動強度.
Water Injected Oil-free Screw Compressor Maintenance
① 需要長時間停止時, 檢查機器電路是否正常. 同時, 排空系統內的潤滑水. 也, close all openings of the oilless screw air compressor. 為了防止受潮, dust intrusion, 和生鏽.
② The water-injected screw compressor is not used for some time. 重新啟動機器時, 先向分離器添加潤滑水. 添加至中間水位. 然後打開壓縮機主機. Manually add purified water to the middle level of the airend. 此外, manually rotate the air compressor several times. Prevent the airend from burning due to lack of water when starting.
③ 當溫度低於0℃時, should stop the oil-free rotary screw air compressor, and drain the water in the system. 否則, 如果結冰了, 它會損壞主機.
④ Compressor filter maintenance:
First-time maintenance: 200~800小時更換空氣濾清器和水濾清器.
定期保養: replace the filters every 2000~3000 hours.
主機維護: every two years.
Oil-free Rotary Screw Air Compressor vs Oil-injected Screw Compressor
(1) 更高的壓縮空氣質量
首先, 無油螺桿空氣壓縮機生產 100% 無油空氣. 這個優勢很明顯. 還有一點也不容忽視. 水潤滑空壓機系統溫度可達45℃. This is lower than that of an oil-injected screw compressor. 所以空氣的含水量也會更低.
所以更清潔的空氣對後面的烘乾機來說更好. 可以減輕烘乾機的工作負荷, and increase the water removal performance. 也, reduces the corrosion of the refrigeration dryer pipeline. 此外, 它還可以增加干燥劑乾燥機吸附劑的使用壽命.
(2) 更節能
這是因為空氣損失較低. 對於後者, 它需要去除空氣中的油. 所以需要添加相應的過濾器. 最終, it will increase pressure loss. 但我們必須滿足最終氣壓. 所以, 後者的排氣壓力必須高於無油螺桿空壓機的排氣壓力. 無油螺桿壓縮機的排氣壓力為 1.5 條形低於後者. 能源消耗為 10% 降低. 所以, 無油壓縮機電費更低.
(3) Lower Maintenance Cost
這是因為空氣損失較低. 對於後者, 它需要去除空氣中的油. 所以需要添加相應的過濾器. 最終, it will increase pressure loss. 但我們必須滿足最終氣壓. 所以, 後者的排氣壓力必須高於無油螺桿空壓機的排氣壓力. 無油螺桿壓縮機的排氣壓力為 1.5 條形低於後者. 能源消耗為 10% 降低. 所以, 無油壓縮機電費更低.
20m3/min 注油量 螺桿壓縮機 |
20m3/min 注水量 螺桿壓縮機 |
||
更換潤滑油 3 次/年 | 120 L * 40 中國新年 / L * 3 次數= 14400 中國新年 |
換水 100 小時/時間 | 120 L*80次/1000*4=38.4元 |
更換油分離器 篩選 3 次/年 |
(2600+1400)*3=12000元 | 不 | / |
更換機油濾清器 3 次/年 | 320*3=960元 | 更換水過濾器 1000 小時/時間 (受壓差報警影響) |
8*170*7=9520元 |
更換空氣過濾器 3 次/年 | 300*3=900元 | 還要更換空氣濾清器 3 次/年 | 1000*3=3000元 |
將元素替換為 壓縮空氣過濾器2個/年 |
3000*2=6000元 | 軟水機 3 年/時間 | 3000 元/3=1000元 (分配計算) |
1 年機油保養費用 噴射式螺桿壓縮機 |
34,260 元/年 | 1 無油一年維護費用 螺桿空氣壓縮機 |
13673.6 元/年 |
總結, 無油水潤滑空壓機的維護成本更低.
常見問題解答
(1) Is the water content in the air larger than other air compressors?
The water-injected screw compressor is an isothermal compression. 排氣溫度45℃左右. 氣態水的產生是有條件的. 那是, needs to heat up to above 65 ℃. 所以, 也沒有蒸氣水.
一般來說, the compressed air has no liquid water. 其含水量的決定因素來自於水氣分離系統. 總之, 壓縮機內無氣態水. 液態水也可以完全分離.
The water content of our oil-free screw compressor is 15% 低於環境空氣. It’s lower water content than the oil-injected screw type. 除了, 每台無油機都會經過專業的露點儀測試. 出廠前含水量合格.
(2) 無油水潤滑主機是不是就像一艘天然的“細菌船”? 排出的空氣細菌含量高嗎?
水中細菌的生長是有前提的. 那是, 在密封空間內停留時間超過 72 小時. But the water in the oil-free screw air compressor is always circulating.
Part of the water is automatically drained every 200 小時. 同時, 它會加一些水. 水可以沖走細菌和灰塵. 而且, 過濾器還可以去除一些細菌. 所以, 壓縮空氣中含有很少的細菌.
此外, 進氣閥、壓力閥均密封. The water inside cannot be in contact with the air at all. 所以不存在細菌滋生的條件. 當然, 有時我們對空氣質量有極高的要求. 在這種情況下, it can add an anti-bacterial filter.
(3) Will the oil-free water-injected screw compressor consume a lot of water?
無需不斷向空壓機加水. 就像洗衣機一樣. 裡面有一個水位傳感器. 具有自動排水、自動補水功能.
例如, there is a 110KW water-injected screw compressor. 潤滑油水量為 130 升. 一年計算如下 8000 小時. 需要交換一下 6000 升水. 那是 6 噸水. 即使翻倍, 那是 12 噸. 5 元/噸水. 每年的水費僅為 60 中國新年. 所以既省水又省錢.
(4) 水的潤滑效果好嗎? 空壓機使用壽命長嗎?
首先, water has several roles in oil-free screw air compressors. 那是, 冷卻, sealing, 和潤滑. 第二, we usually use SUS304 material in the airend and system of water-injected screw compressor. 其穩定性經過市場檢驗.
在空氣質量方面, 它是純無油的. 節能率高. 從而證明其先進的技術品質.
此外, 它的結構是完美的. 這導致其完全對稱平衡壓縮. It vibrates less and the noise is lower. 軸承使用壽命可達 70,000 到 100,000 小時. 所以不會影響整個壓縮機的正常使用. The design life of our water-lubricated screw compressor is 25 年. 並且可以連續運行 24 一天幾個小時.